Product ID:WATERBORNE RUST INHIBITING PRIMER-LIGHT, 3860-4702
MSDS Date:08/11/1995
FSC:8010
NIIN:00N072764
MSDS Number: CBYXD

CARDINAL INDUSTRIAL FINISHES

1329 POTRERO AVE
SOUTH EL MONTE, CA 91733
US

Emergency Phone: 800-424-9300 (CHEMTREC)

Info Phone: 818-444-9274

Preparer: BOB SYPOWICZ

Cage: 65860

CARDINAL INDUSTRIAL FINISHES

SOUTH EL MONTE, CA 91733 US

Telephone: 818-444-9274 OR 213-283-9335

Cage: 65860

0.9 @ 20C

CAS: 111-76-2

RTECS: KJ8575000

Fraction By Weight: 4.58%

OSHA PEL 50 PPM, S

ACGIH TLV: 25 PPM, S

0.8 @

CAS: 112-34-5

RTECS: KJ9100000

Fraction By Weight: 1.51%

OSHA PEL 25 PPM (MFR)

ACGIH TLV: N/K

PHTHALIC ACID, BENZYL BUTYL ESTER; (BUTYL BENZYL PHTHALATE)

CAS: 85-68-7

RTECS: TH9990000

Fraction By Weight: 1.06%

OSHA PEL N/K

ACGIH TLV: N/K

EPA Report Quantity: 100 LBS

DOT Report Quantity: 100 LBS

3); (ZINC PHOSPHATE)

CAS: 7779-90-0

RTECS: TD0590000

Fraction By Weight: 5.78%

OSHA PEL 15 MG/M3 (MFR)

ACGIH TLV: 10 MG/M3 (MFR)

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYES: CAN CAUSE IRRITATION AND
REDNESS, TEARING OR BLURRED VISION. SKIN: MILD IRRITATION POSSIBLE
FROM PROLONGED EXPOSURE. INHALATION: NASAL IRRITATION, HEADACHE,
DIZZINESS, NAUSEA, WEAKNESS OR VOMITING. INGESTION:
GASTROINTESTINAL IRRITATION, HEADACHE, DIZZINESS, NAUSEA, WEAKNESS
OR VOMITING. (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT.
Effects of Overexposure:HLTH HAZ: CHRONIC: ANIMAL STUDIES CLEARLY
DEMONSTRATED DOSE-RELATED ADVERSE EFFECTS ON THE CNS, THE
HEMATOPOIETIC TISSUES, THE BLOOD, THE KIDNEYS AND THE LIVER,
ASSOCIATED WITH THE ADMINISTRATION OF E THYLENE GLYCOL MONOBUTYL
ETHER (EGBE) (EXTRACTED FROM DHHS (NIOSH) PUBLICATION # 90-118) .
Medical Cond Aggravated by Exposure:PREEXISTING RESPIRATORY CONDITIONS,
PREEXISTING SKIN DISORDERS, LIVER AND KIDNEY DISORDERS.

First Aid:EYES: FLUSH WITH WATER FOR AT LEAST 15 MINUTES. GET MEDICAL
ATTENTION IMMEDIATELY. SKIN: WASH EXPOSED AREA WITH SOAP AND WATER.
REMOVE CONTAMINATED CLOTHING. INHALATION: REMOVE TO FRESH AIR. IF
BREATH ING IS DIFFICULT, ADMINISTER OXYGEN. IFBREATHING HAS
STOPPED, GIVE ARTIFICIAL RESPIRATION. GET MEDICAL ATTENTION.
INGESTION: INDUCE VOMITING. KEEP PERSON WARM AND QUIET. GET MEDICAL
ATTENTION.

Flash Point Method:TCC
Flash Point:>212F,>100C
Lower Limits:0.3%
Upper Limits:10.6%
Extinguishing Media:FOAM, DRY CHEMICAL, CARBON DIOXIDE, WATER FOG.
Fire Fighting Procedures:WEAR NIOSH APPRVD SCBA & FULL PROT EQUIP .
NOTE! THIS PROD IS A WATERBORNE EMULSION & UNDER NORM OPERATING
CNDTNS PRESENTS MIN RISK OF FIRE OR (SUP DAT)
Unusual Fire/Explosion Hazard:CONTAINERS MAY DEFORM OR EXPLODE WHEN
EXPOSED TO EXTREME HEAT. DECOMPOSITION PRODUCT MAY YIELD OXIDES OF
CARBON AND NITROGEN.

Spill Release Procedures:REFER TO OTHER SECTIONS OF THIS MSDS.
ELIMINATE ALL IGNITION SOURCES. ABSORB LIQUID IN ABSORBENT MATERIAL
AND PREVENT SPREADING TO GROUND WATER.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:PVNT FREEZING. CONTRS MAY BE HAZ WHEN
EMPTIED. SINCE EMPTIED CONTRS RETAIN PROD RESIDUALS (VAP, LIQ,
&/SOLID), ALL HAZ PREC IN MSDS MUST BE OBSERVED.
Other Precautions:PAINT AND SOLVENTS HAVE BEEN LINKED TO LIVER
ABNORMALITIES, KIDNEY AND LUNG DAMAGE. ALTHOUGH THIS COATING IS A
WATERBORNE OF LOW TOXICITY, FOLLOW PRECAUTIONS OF THIS MSDS TO
PREVENT OVEREXPOSURE.

Respiratory Protection:IF TLV OF PROD/ANY COMPONENT IS EXCEEDED, A
NIOSH APPRVD AIR SUPPLIED RESP IS ADVISED IN ABSENCE OF ENVIRON
CTL. OSHA REGS ALSO PERMIT OTHER NIOSH APPRVD RESPS UNDER SPECIFIED
CNDTNS (SEE YOUR SFTY EQ UIP SUPPLIER). ENGINEERING OR (SUP DAT)
Ventilation:PROVIDE SUFFICIENT MECHANICAL (GENERAL AND/OR LOCAL
EXHAUST) VENTILATION TO MAINTAIN EXPOSURE BELOW TLV(S).
Protective Gloves:CHEMICAL AND SOLVENT RESISTANT GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS .
Other Protective Equipment:EMER EYEWASH & DELUGE SHOWER MEETING ANSI
DESIGN CRITERIA . PVNT RPTD/PRLNG SKIN CONT W/GB PROT HAND (SUP
DAT)
Work Hygienic Practices:WASH HANDS BEFORE EATING OR USING RESTROOM,
SMOKE IN SMOKING AREAS ONLY.
Supplemental Safety and Health
FIRE FIGHT PROC: EXPLO. HOWEVER, PROPER STOR, & CAUTION IN HNDLG & USE
PRACT SHOULD BE USED AT ALL TIMES. RESP PROT: ADMINISTRATIVE
CONTROLS SHOULD BE IMPLEMENTED TO REDUCE EXPOS. OTHER PROT EQUIP:
CR EAM, WEAR IMPERVIOUS CLTHG & CHEM RESIST BOOTS.

Boiling Pt:B.P. Text:>212F,>100C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
VOC Pounds/Gallon:196
Evaporation Rate & Reference:SLOWER THAN ETHER
Appearance and Odor:NONE SPECIFIED BY MANUFACTURER
Percent Volatiles by Volume:47.89

Stability Indicator/Materials to Avoid:YES
AVOID CONTAMINATION WITH ALKALIS.
Stability Condition to Avoid:EXTREME TEMPERATURES.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.

Waste Disposal Methods:DESTROY BY LIQUID INCINERATION IN ACCORDANCE
WITH APPLICABLE REGULATIONS. CONTAMINATED ABSORBENT SHOULD BE
INCINERATED OR SENT TO APPROVED LANDFILL IN ACCORDANCE WITH LOCAL,
STATE, AND FEDERAL REGULAT IONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.